Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB085  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  EL BURRITO LOCO Address  600 S MAIN ST
Owner or Operator   HORACIO BARRIOS City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
X
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
  
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
X
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
X
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
X
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
X
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   CHLORINE 50-100 ppm                   Dishwasher Temperature   NA °F or label
Food Temperatures:   STEAK 40, MOZZARELLA CHEESE 41, AVOCADO 39, PORK 38, RICE 140, GROUND BEEF 142, CHICKEN 145, PORK 150, REFRIED BEANS 40, CHICKEN 39
 
General Comments
HACCP CONCEPTS DISCUSSED: WASH HANDS PROPERLY FOR 20-30 SECONDS BEFORE PREPARING ANY FOOD TO AVOID CONTAMINATION OF FOOD. 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  07/10/2017 Time In  10:45 AM Time Out  12:20 PM Sanitation Score  77 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  91  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB085  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  EL BURRITO LOCO Address  600 S MAIN ST
Owner or Operator   HORACIO BARRIOS City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. Chicken was found at 120F in the warming unit. Provide for all cold potentially hazardous foods to be held at 41°F or below at all times except during necessary periods of preparation. 750.120 Immediate/Onsite
*20  Observed the sanitizer solution to be too weak at the following location(s). Sanitizer is too weak at the three compartment sink. Provide for the sanitizer solution to be mixed to the appropriate level for the type of sanitizer being used. Employee adjusted sanitizer. 750.830 Immediate/Onsite
*41  Observed the following toxic chemical container(s) to not be properly labeled: Chemicals have no label on spray bottles. Provide for all chemical containers that no longer have the original label on them to be labeled with chemical content. Chemicals Immediate/Onsite
5  Observed no thermometer to be available in the following units. There is no visible thermometer in large prep cooler. Provide for an accurate, conspicuous thermometer, that is accurate within +/- 3°F, to be available in all units holding potentially hazardous foods. 750.140 Next Inspection
8  Observed the following food products to be improperly stored. 1. No lid on sugar on cook line. 2. No lids on salsa. Provide for all food products in storage to have proper covers or overhead protection. 750.130 Next Inspection
10  Observed the following utensil(s) to be improperly stored. Food scoop handle found in Molido and chicken base. Provide for all utensils to be stored in one of the following manners: 1) Clean and dry 2) In the food product with the handle up and out of the food product 3) In a dipper well, using potable water 4) Malt collars and frozen dessert utensils either clean and dry or in a dipper well. Next Inspection
14  Observed the following improper food contact surfaces. Small cutting board has a lot of knife grooves in it. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbent, corrosive resistant, and light colored Next Inspection
17  Observed no test kit to be available for testing the chemical sanitizer. Provide for a test kit or other device that accurately measures the parts per million concentration of the sanitizer solution to be available. 750.690 Next Inspection
21  Observed the following wiping cloth(s) to be improperly stored: Soiled wiping cloths found on prep line. Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used. 750.830 Next Inspection
23  Observed the following contact surfaces to be unclean Clean and maintain Next Inspection
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  07/10/2017 Time In  10:45 AM Time Out  12:20 PM Sanitation Score  77 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  91  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB085  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  EL BURRITO LOCO Address  600 S MAIN ST
Owner or Operator   HORACIO BARRIOS City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  07/10/2017 Time In  10:45 AM Time Out  12:20 PM Sanitation Score  77 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  91